A novel dual feedwater circuit for a parabolic trough solar power plant

The validated dynamic model of a parabolic trough power plant (PTPP) is improved by the combination of a new feedwater circuit (feedwater/HTF circuit) and a reference feedwater circuit (feedwater/steam circuit) as well as the development of the steam turbine model. Such design represents the first effort of research to utilize a dual feedwater circuit inside the PTPP to increase the power output in the daylight from 50 to 68 MW(el) and raise night operating hours at a lower cost. The purpose of increasing the operating night hours at a power (48 MW(el)) as in the reference PTPP is to get rid of the fossil fuel backup system and rely only on the absorbed solar energy and the stored energy in the molten salt. During daylight hours, the feedwater circuit is operated using Feedwater/HTF. In the transient period, the feedwater/HTF circuit will gradually be closed due to a decrease in solar radiation. Furthermore, the rest of the nominal feedwater mass flow rate (49 kg/s) is gradually replenished from the feedwater/steam circuit. After sunset, the entirety of the feedwater is heated based on the steam extracted from the turbine. The purpose of this improvement is to raise the number of nightly operational hours by reducing the nominal load from 61.93 to 48 MW(el) as a result of low energy demand during the evening hours. Therefore, a comparison study between the reference model and this optimization (optimization 2) is conducted for clear days (26th–27th/June and 13th–14th/July 2010) in order to understand the influence of dual feedwater circuit. The comparison indicates that the operational hours of the power block (PB) will be obviously increased. Moreover, this improvement reduces based on the fossil fuel system at night. As the last step, an economic analysis was performed on the costs of the referenced and the optimized PTPP as a function of the levelized energy cost (LEC). The results illustrate that the specific energy cost of a PTPP with 7.5 h of storage capacity is lowered by about 14.5% by increasing the output of the PTPP from 50 to 68 MW(el).