Partial Replacement of Soybean Meal with Canola Meal or Corn DDGS in Low-Protein Diets Supplemented with Crystalline Amino Acids—Effect on Growth Performance, Whole-Body Composition, and Litter Characteristics

SIMPLE SUMMARY: Dietary protein reduction with amino acid supplementation is a nutritional approach to reducing environmental pollution. Soybean meal is nutritionally superior to alternative protein feedstuffs, such as corn distillers dried grain with solubles (cDDGS) and canola meal (CM), because of its relatively good balance of amino acids. This study investigated the usage of CM or cDDGS compared to SBM in low-protein broiler diets and their effects on growth performance, carcass yield, whole-body composition, and litter characteristics. The results demonstrated that replacing soybean meal with cDDGS or CM negatively affected the performance of the birds, whereas reducing dietary protein reduced the litter surface ammonia, irrespective of protein feedstuff. Therefore, complete replacement of SBM with cDDGS or CM in low-protein diets is not feasible for optimum performance in broiler chickens. ABSTRACT: A 42-day study was conducted to explore the application of supplemental amino acids (AA) in low-protein diets with soybean meal (SBM), canola meal (CM) or corn distillers dried grain with solubles (cDDGS) as the main protein feedstuffs. The responses of interest were growth performance, carcass yield, whole-body composition, litter ammonia and litter N. On d 0, a total of 540 Cobb 500 (off-sex) male broilers were allocated to 36 floor pens. All the birds received one starter diet that met nutrient requirements during the first 10d. Thereafter, six experimental diets were provided in grower and finisher phases. The diets included a positive control (PC): a corn–SBM diet with adequate protein. The protein level of the negative control (NC) was decreased by 45 g/kg relative to the PC. The next two diets had the same protein levels as the NC but with cDDGS added at 50 or 125 g/kg. The last two diets had the same CP as the NC but with CM added at 50 or 100 g/kg. All the low-protein diets had the same level of standardized ileal digestible indispensable AA according to Cobb 500 recommended level. Gly and Ser were added as sources of non-specific N. The dietary protein reduction in corn–SBM diets at both phases decreased (p < 0.05) weight gain and increased (p < 0.05) feed conversion ratio (FCR). Increasing levels of cDDGS or CM, at a constant CP level, linearly decreased (p < 0.05) the weight gain and feed intake, whereas increasing CM level linearly increased (p < 0.05) FCR in the grower and finisher phases. The eviscerated and carcass yields decreased, whereas the fat yield increased (p < 0.05) with reduced protein in corn–SBM diet. Increasing levels of cDDGS and CM at a constant CP level quadratically decreased (p < 0.05) the eviscerated weight, whereas the fat weight linearly decreased (p < 0.05) with increasing levels of cDDGS and CM. The birds receiving the PC diet had a lower (p < 0.05) lean muscle (%) and a higher fat (%) compared to birds receiving the NC diet at d 21. However, on d42, birds receiving the PC diet had decreased (p < 0.05) bone mineral density, bone mineral content and lean weight compared to those receiving the NC diet. The litter ammonia increased (p < 0.05) with the increasing levels of protein in the SBM diets. In conclusion, 50 g/kg inclusion levels of CM and cDDGS at the same low-protein levels as SBM produced a similar growth response to the NC, whereas higher levels were detrimental. Hence under the conditions of the current experiment, complete replacement of SBM with DDGS or CM in low-protein diets was not feasible.